Slow driving
拐弯要慢。搅拌车重心高,易侧翻!入弯之前提前减速减挡,尽量别拐弯的时候踩刹车。随时通过后视镜注意观察罐子是否在转,把转速尽量调慢,转速过高,车辆容易摆动;倒车要慢。别总是把头伸出窗外,要看着两边后视镜一起兼顾,实在不确定就停车看清楚再倒,好多路面是挖掘机刚刚铺的比较软,车容易陷。
Turn slowly. The mixer truck has a high center of gravity and is easy to roll over! Decelerate and downshift in advance before turning, and try not to step on the brake when turning. Observe whether the tank is rotating through the rearview mirror at any time, and slow down the speed as much as possible. If the speed is too high, the vehicle is easy to swing; Reverse slowly. Don't always stick your head out of the window. Look at the rear-view mirrors on both sides. If you're really uncertain, stop and look clearly before falling down. Many roads are just paved by excavators, which are relatively soft, and the car is easy to sink.
低速挡过“烂路”
Low gear over "rotten road"
遇到路面不平,坑坑洼洼地方用合适的低速挡通过,保证车随时有爆发力。木板,尖石子一定要避让,尤其重车!
In case of uneven road surface and potholes, use appropriate low-speed gear to ensure that the car has explosive power at any time. Boards and sharp stones must be avoided, especially heavy cars!
上坡提前减档
Upslope advance downshift
如果拉得满的话,注意起步要平缓,上坡更要注意,不能乱减档,最好提前减档。而且最大好加快灌子的转速,以免混凝土流出。
If it's full, pay attention to a gentle start and pay more attention when going uphill. You can't downshift randomly. It's best to downshift in advance. Moreover, it is best to speed up the speed of the pouring to prevent the concrete from flowing out.
下坡忌重车空挡滑行
Do not slide the heavy vehicle in neutral gear downhill
长时间行驶或者下坡前都要习惯的测试一下刹车。切勿重车空挡滑行下坡,下坡拐弯时提前减速再减挡再减速,带挡刹车效果最好。
Be used to testing the brakes before driving for a long time or going downhill. Do not slide down the slope with the loaded vehicle in neutral. When turning down the slope, slow down in advance, then reduce the gear, and then slow down. The braking effect with gear is the best.
注意限高问题
Pay attention to the height limit
不论是工地的路况复杂,或者是运输行驶过程中,要小心树木、电线等,特别是要防止刮到电线。
Whether the road conditions on the construction site are complex or during transportation, be careful of trees, wires, etc., especially to prevent scraping wires.
下车查看倒车线路
Get out of the car and check the reversing line
在工地,晚上工作先下车拿电筒查看倒车路线。哪里有障碍物,有坑或者比较松软的地方,都一一记下,遇到钢筋钉子之类的及时清理。
![混凝土搅拌车](http://capemaycitypolice.com/uploadfile/2021/0811/20210811114710774.png)
At the construction site, get off at night and check the reversing route with a flashlight. Where there are obstacles, pits or soft places, write them down one by one, and clean up in time in case of reinforcement nails and the like.
卸料前准备工作
Preparation before unloading
让混凝土充分搅拌,必要时可以加一些水,让混凝土搅拌得更均匀,也方便卸料;放料时把车尽量停在平地上放料前先把出料斗溜槽打湿,方便清洗。
Allow the concrete to be fully mixed. If necessary, add some water to make the concrete mix more evenly and facilitate unloading; When discharging, park the truck on the flat ground as far as possible. Wet the chute of the discharge hopper before discharging to facilitate cleaning.
卸料时不要大意
Don't be careless when unloading
放料时最好自己看着,免得放料工乱操作放料操作杆,每次罐子正反转中间位子时最好停一下,保护减速机,托轮等。
It's best to watch by yourself when discharging, so as to avoid the discharging operator's random operation of the discharging operating rod. It's best to stop every time the tank is reversing the middle position to protect the reducer, supporting wheel, etc.
清洗搅拌罐
Clean the mixing tank
洗罐子时一定要仔细的冲洗干净,并把水反复的正反转两次,再放出来,最后一趟时把水箱的水全部放进罐子,再回到站加水彻底清洗罐子。
When washing the tank, be sure to wash it carefully, and repeat the positive and negative rotation of the water twice, and then release it. In the last trip, put all the water in the water tank into the tank, and then return to the station to add water to clean the tank thoroughly.
好的产品成就好的服务,好的厂家成就好的作品,混凝土搅拌车坚持为客户提供优质的服务,详情请继续关注我们的网站://capemaycitypolice.com
Good products make good services, and good manufacturers make good works. Concrete mixers insist on providing customers with high-quality services. Please continue to pay attention to our website for details: //capemaycitypolice.com